Hyundai Tucson: Rear Wiper/Washer / Rear Wiper Motor Repair procedures

Hyundai Tucson (LM) 2010-2015 Service Manual / Body Electrical System / Rear Wiper/Washer / Rear Wiper Motor Repair procedures

Inspection

Rear Wiper Motor

1.	Remove the 4P connector from the rear wiper motor.

2.	Connect battery positive (+) and negative (-) cables to terminals 2 and 1 respectively.

Check that the motor operates normally. Replace the motor if it operates abnormally.

No	Description	No	Description
1	GND	3	Parking
2	Switch	4	IGN(+)

Automatic Stop Operation Check

1.	Operate the motor at low speed using the stalk control.

2.	Stop the motor operation anywhere except at the off position by disconnecting terminal 2.

3.	Connect terminals 2 and 3.

4.	Connect the positive (+) lead from the battery to terminal 4 and the negative (-) lead to terminal 1.

5.	Check that the motor stops running at the off position.

Removal

1.	Detach the rear wiper head cap (A).

2.	Remove the rear wiper arm & blade (A) after removing rear wiper arm nut (B).

3.	Remove the rear wiper cover (A) and HEX nut (B).

4.	Remove the pad cap (A).

5.	Open the liftgate then remove the liftgate trim. (Refer to the BD group - "Liftgate")

6.	Disconnect the rear wiper motor connector (A) then remove the rear wiper motor (B) after loosening bolts (2EA).

Installation

Install the rear wiper motor assembly.

Tightening torque Nut :

7~10 Nm (0.7~1.0 kgf.m, 5~7.4 lbf.ft)

Do not reuse the rubber pad if it is dameged.

2.	Install the liftgate trim. (Refer to the BD group - "Liftgate")

Insert the pad cap and HEX nut.

Tightening torque :

4~7 Nm (0.4~0.7 kgf.m, 2.9~5.0 lbf.ft)

4.	Install the rear wiper arm and blade to align with black lowest rear defogger line (A).

Install the rear wiper arm and rear wiper nut.

Tightening torque Nut :

14~17 Nm (1.4~1.7 kgf.m, 10~12 lbf.ft)

Components and Components Location

Component Location 1. Rear wiper motor assembly2. Motor support3. Rubber pad4. Liftgate glass hole5. Pad cap6. HEX nut7. Cover8. Rear wiper arm & blade9. Rear wiper arm nut10. Head cap11. Rea ...

Rear Washer Switch Repair procedures

Inspection Check for continuity between the terminals while operating the wiper and washer switch. If it is not normal condition, replace wiper and wiper switch. [LHD] [RHD] Rear Wiper S ...

Other information:

Hyundai Tucson (LM) 2010-2015 Owners Manual: Answering Calls
Answering a Call Answering a call with a Bluetooth® Wireless Technology device connected will display the following screen. To accept the call, press key on the steering wheel while the call is incoming. 1) Caller : Displays the other party’s name when the incoming caller is saved wit ...

Hyundai Tucson (LM) 2010-2015 Owners Manual: Changing Priority
What is Priority? It is possible to pair up to five Bluetooth® Wireless Technology devices with the car audio system. The "Change Priority" feature is used to set the connection priority of paired phones. Press the key Select [Phone] Select [Paired Phone List] From the paired ph ...