Hyundai Tucson: Seat Belt Pretensioner / Seat Belt Pretensioner (BPT) Repair procedures

Hyundai Tucson (LM) 2010-2015 Service Manual / Restraint / Seat Belt Pretensioner / Seat Belt Pretensioner (BPT) Repair procedures

Removal

1.	Disconnect the battery negative cable, and wait for at least three minutes before beginning work.

2.	To remove the seat belt anchor pretensioner (C), keep on pushing the lock pins (A) as arrow direction. And then remove the seat belt after pushing the lock pin (B).

Remove the following parts. (Refer to the Body group- Interior trim)

A.	Door scuff trim

B.	Center pillar trim

4.	Remove the upper anchor bolt.

5.	Disconnect the Seat Belt Pretensioner connector.

6.	Loosen the Seat Belt Pretensioner mounting bolt and remove the Seat Belt Pretensioner.

Installation

1.	Remove the ignition key from the vehicle.

2.	Disconnect the battery negative cable and wait for at least three minutes.

Install the Seat Belt Pretensioner (BPT) with a bolt.

Tightening torque:

Bolt B: 39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

4.	Connect the Seat Belt Pretensioner (BPT) connector.

Install the upper anchor bolts.

Tightening torque:

39.2 ~ 53.9 N.m (4.0 ~ 5.5 kgf.m, 28.9 ~ 39.8 lb-ft)

Install the following parts. (Refer to the Body group- Interior trim)

A.	Center pillar trim

B.	Door scuff trim

Insert the seat belt to the anchor pretensioner.

Make sure the lock pin is connected in properly.

8.	Reconnect the battery negative cable.

After installing the Seat Belt Pretensioner (BPT), confirm proper system operation:

A.	Turn the ignition switch ON; the SRS indicator light should be turned on for about six seconds and then go off.

Seat Belt Pretensioner (BPT) Components and Components Location

Components ...

Anchor Pretensioner Description and Operation

Description Anchor pretensioner operates as well as belt Pretensioner at the same time If it gets into its deploy condition after a collision. It is located at near anchor on front seat and it ...

Other information:

Hyundai Tucson (LM) 2010-2015 Owners Manual: Sound Settings
Press the key Select [Sound] through TUNE knob or key Select menu through TUNE knob Sound Settings This menu allows you to set the ‘Bass, Middle, Treble’ and the Sound Fader and Balance. Select [Sound Settings] Select menu through TUNE knob Turn T ...

Hyundai Tucson (LM) 2010-2015 Service Manual: 35R Clutch Control Solenoid Valve(35R/C_VFS) Specifications
Specifications Direct control VFS[35R/C] x Control type : Normal high type Control Pressure kpa (kgf/cmx, psi) 500.14 ~ 9.81(5.1 ~ 0.1, 72.54 ~ 1.42)Current value(mA)50 ~ 850 Internal resistance(x)5.1 ...