Hyundai Tucson: Controller / Heater & A/C Control Unit(Manual) Repair procedures

Hyundai Tucson (LM) 2010-2015 Service Manual / Heating, Ventilation and Air Conditioning / Controller / Heater & A/C Control Unit(Manual) Repair procedures

Replacement

1.	Disconnect the negative (-) battery terminal.

2.	Remove the console upper cover (A).

3.	Using the screwdriver, remove the center facia lower cover (A).

4.	Using the screwdriver, remove the center facia lower switch assembly (A).

5.	Disconnect the connectors and then remove the center facia lower switch assembly (A).

6.	Loosen the control panel mounting screws and then remove the control panel (A).

7.	Disconnect the connectors and then remove the control panel (A).

8.	Install in the reverse order of removal.

Heater & A/C Control Unit(Manual) Components and Components Location

Components Connector Pin Function ConnectorPin NoFunctionConnectorPin NOFunctionConnector(A)1Middle HighConnector(B)1Tail Lamp (ILL+)2-2Battery 3GND3Mode Actuator (VENT)4High4Mode Actuator (DEF)5M ...

Heater & A/C Control Unit(Dual) Components and Components Location

Components Control Panel Connector Pin Function ConnectorPin NOFunctionConnectorPin NOFunctionConnector(A)1BatteryConnector(B)1CAN (LOW)2Tail Lamp (ILL+)2CAN (HIGH)3IG23Intake Actuator (F/B)4DR ...

Other information:

Hyundai Tucson (LM) 2010-2015 Service Manual: Delivery Pipe Repair procedures
Removal In case of removing the high pressure fuel pump, high pressure fuel pipe, delivery pipe, and injector, there may be injury caused by leakage of the high pressure fuel. So don’t do any repair work right after engine stops. 1. Turn the ignition switch OFF ...

Hyundai Tucson (LM) 2010-2015 Service Manual: Exhaust Manifold Components and Components Location
Components 1. Heat protector2. Exhaust manifold gasket3. Exhaust manifold4. Exhaust manifold stay ...