Hyundai Tucson: Cooling System / Water pump Components and Components Location

Hyundai Tucson (LM) 2010-2015 Service Manual / Engine Mechanical System / Cooling System / Water pump Components and Components Location

Components

1. Water pump pulley
2. Water pump
3. Water pump gasket
4. Water inlet fitting

5. Thermostat
6. Water temperature control assembly
7. Engine coolant temperature sensor
8. Bypass hose

9. Heater pipe & hose assembly
10. Throttle body coolant hose

Radiator Repair procedures

Inspection Radiator Cap Testing 1. Remove the radiator cap, wet its seal with engine coolant, and then install it on a pressure tester. 2. Apply a pressure of 93.16~122.58 kPa (0.95~1.25 kgf/ ...

Water pump Repair procedures

Removal and Installation 1. Loosen the drain plug, and then drain the engine coolant. Remove the radiator cap to help drain the coolant faster. 2. Remove the drive belt. (Refer to Timing sys ...

Other information:

Hyundai Tucson (LM) 2010-2015 Service Manual: Intake Manifold Repair procedures
Removal and Installation 1. Remove the engine cover. 2. Disconnect the battery negative terminal. Tightening torque: 3.9 ~ 5.9 N.m (0.4 ~ 0.6 kgf.m, 3.0 ~ 4.4 lb-ft) 3. Disconnect the wiring connectors and harness clamps, and then remove the wiring and protectors from the intake m ...

Hyundai Tucson (LM) 2010-2015 Service Manual: Instrument Cluster Schematic Diagrams
Circuit Diagram (1) Circuit Diagram (2) Massage Flow Diagram ...