Hyundai Tucson: Exterior / Tail Gate Repair procedures

Replacement
Tail Gate Trim Replacement
   
When prying with a flat-tipped screwdriver, wrap it with protective tape, and apply protective tape around the related parts, to prevent damage.
Put on gloves to protect your hands.
Make sure the tailgate locks/unlocks and opens/closes properly.
1.
Remove the upper trim (B).
2.
After loosening the mounting screws, then remove the tailgate trim (C) and side trim (A).
3.
Install in the reverse order of removal.
   
Replace and damaged clips.
Make sure the opens securely

Tail Gate Latch Replacement
1.
Remove the tail gate trim.
2.
After loosening the mounting bolts, then remove the latch assembly (A).

Tightening torque :
6.9 ~ 10.8 N.m (0.7 ~ 1.1 kgf.m, 5.1 ~ 8.0 lb-ft )

3.
Install in the reverse order of removal.
   
Make sure the tail gate opens properly.
Tail Gate Lift Replacement
   
Take care not to be closed the tail gate, when removing the life.
1.
Using a screwdriver (A), lift the socket clip (B) up slightly on both ends of the lifter (D), and then remove the lifter from the bracket (C).

2.
Push the socket of the lifter into the bracket for installation.
   
Make sure the tailgate locks/unlocks and opens/closes properly.
Tail Gate weatherstrip Replacement
   
Do not apply sealant to the body.
1.
Remove the tail gate weatherstrip (A).

2.
Install in the reverse order of removal.
   
Install the weatherstrip aligned with canter line (B).
Adjustment
1.
Check that the door and body edges are parallel.
2.
After loosening the tailgate hinge (A) mounting bolt, adjust the tailgate by moving it up or down, or right or left.
3.
Adjust the striker (D) by moving it up or down, or right or left.
4.
Make sure the trunk lid opers and locks securely.

Hood Repair procedures
Replacement Hood Assembly Replacement     • When removing and installing the hood, an assistant is necessary. • Take care not to damaged the hood and body. • ...

Front Door Components and Components Location
Components 1.Door inside handle housing2. Door trim3. Door belt inner weatherstrip 4. Door screen 5. Door module 6. Quadrant inner cover 7. Door panel 8. Door belt outside weatherstrip9. Door si ...

Other information:

Hyundai Tucson (LM) 2010-2015 Owners Manual: Tire chains
Since the sidewalls of radial tires are thinner than other types of tires, they may be damaged by mounting some types of tire chains on them. Therefore, the use of snow tires is recommended instead of tire chains. Do not mount tire chains on vehicles equipped with aluminum wheels; if unavoi ...

Hyundai Tucson (LM) 2010-2015 Owners Manual: Digital clock
To set the time: The ignition switch must be in the ACC position or the ON position.  With Audio off 1. Press the CLOCK button until the clock display blinks. 2. Set the clock by using the TUNE knob. WARNING Clock setting Do not adjust the clock while driving, you may lose steering c ...

© 2010-2024 www.htmanual.net