Troubleshooting |
Symptom | Suspect Area | Remedy |
Water leaks from panoramaroof | Deteriorated roof lid weatherstrip | Replace |
Excessive roof lid-to-body clearance andImproperly fitted weatherstrip | Adjust | |
Wind noise around sunroof | Loose or deformed deflector, gapsIn body work | Retighten adjust or replace |
Noise heard when opening/ closing panoramaroof | Foreign particles lodged in guide rail | Check drive cable and guide rails for foreign particles |
Loose guide rails and lid | Retighten | |
Motor runs but sunroof does not move or moves only partially | Foreign particles lodged in guide rail | Adjust or replace |
Incorrect engagement of motor pinion with drive cable | ||
Decrease in motor`s clutch slipping force | ||
Increased sunroof sliding resistance or interference of sunroof
with drive cables, weatherstrip, etc. due to maladjustment of sunroof | ||
Noise in motor (clutch slipping noise from motor when sunroof is fully opened or closed is not an unusual noise | Incorrect engagement of motor pinion with drive cable | Check pinion installation and retighten motor |
Worn out or damaged motor pinion bearing | Replace motor assembly | |
Worn out or deformed drive cable | Replace | |
Door glass fails to operateUp and Down | Incorrect window glass installation | Adjust position |
Damaged or faulty regulator arm or regulator | Correct or replace | |
Door does not open or closecompletely | Incorrect door installation | Adjust position |
Defective door check assembly | Correct or replace | |
Door hinge requires grease | Apply grease | |
Hood does not open or close completely | Striker and latch not properly aligned | Adjust |
Incorrectly installed hood | Adjust | |
Incorrect hood bumper height | Adjust | |
Water leak through windshield and rear window | Defective seal | Fill with sealant |
Defective flange | Correct |
Hyundai Tucson (LM) 2010-2015 Service Manual: Instrument Cluster Repair procedures
Removal
1.
Disconnect the negative (-) battery terminal.
2.
Remove the cluster fascia panel (A).
[LHD]
[RHD]
3.
Remove the cluster fascia lower panel (A).
[LHD]
[RHD]
4.
Remove the cluster fascia (A) from the housing after loosening 4 screws.
[LHD]
[RHD]
5.
Disconnect the ...
Hyundai Tucson (LM) 2010-2015 Service Manual: Transaxle Control Module (TCM) Schematic Diagrams
1. TCM Connector and Terminal Function
2. TCM Terminal Function
Connector [A]
PinDescriptionPinDescription1-54-2-55-3-56-4-57-5-58Sport mode down switch6-59Oil temperature sensor (+)7-60-8-61-9-62-10-63-11-64-12-65-13-66-14-67-15-68-16-69-17-70-18-71-19-72-20-73Inhibitor switch signal "S4"21-74 ...