Hyundai Tucson: Rear Wiper/Washer / Rear Wiper Motor Repair procedures

Hyundai Tucson (LM) 2010-2015 Service Manual / Body Electrical System / Rear Wiper/Washer / Rear Wiper Motor Repair procedures

Inspection

Rear Wiper Motor

1.	Remove the 4P connector from the rear wiper motor.

2.	Connect battery positive (+) and negative (-) cables to terminals 2 and 1 respectively.

Check that the motor operates normally. Replace the motor if it operates abnormally.

No	Description	No	Description
1	GND	3	Parking
2	Switch	4	IGN(+)

Automatic Stop Operation Check

1.	Operate the motor at low speed using the stalk control.

2.	Stop the motor operation anywhere except at the off position by disconnecting terminal 2.

3.	Connect terminals 2 and 3.

4.	Connect the positive (+) lead from the battery to terminal 4 and the negative (-) lead to terminal 1.

5.	Check that the motor stops running at the off position.

Removal

1.	Detach the rear wiper head cap (A).

2.	Remove the rear wiper arm & blade (A) after removing rear wiper arm nut (B).

3.	Remove the rear wiper cover (A) and HEX nut (B).

4.	Remove the pad cap (A).

5.	Open the liftgate then remove the liftgate trim. (Refer to the BD group - "Liftgate")

6.	Disconnect the rear wiper motor connector (A) then remove the rear wiper motor (B) after loosening bolts (2EA).

Installation

Install the rear wiper motor assembly.

Tightening torque Nut :

7~10 Nm (0.7~1.0 kgf.m, 5~7.4 lbf.ft)

Do not reuse the rubber pad if it is dameged.

2.	Install the liftgate trim. (Refer to the BD group - "Liftgate")

Insert the pad cap and HEX nut.

Tightening torque :

4~7 Nm (0.4~0.7 kgf.m, 2.9~5.0 lbf.ft)

4.	Install the rear wiper arm and blade to align with black lowest rear defogger line (A).

Install the rear wiper arm and rear wiper nut.

Tightening torque Nut :

14~17 Nm (1.4~1.7 kgf.m, 10~12 lbf.ft)

Components and Components Location

Component Location 1. Rear wiper motor assembly2. Motor support3. Rubber pad4. Liftgate glass hole5. Pad cap6. HEX nut7. Cover8. Rear wiper arm & blade9. Rear wiper arm nut10. Head cap11. Rea ...

Rear Washer Switch Repair procedures

Inspection Check for continuity between the terminals while operating the wiper and washer switch. If it is not normal condition, replace wiper and wiper switch. [LHD] [RHD] Rear Wiper S ...

Other information:

Hyundai Tucson (LM) 2010-2015 Owners Manual: Compass function
The Compass can be turned ON and OFF and will remember the last state when the ignition is cycled. To turn the display feature ON/OFF: 1. Press and release the button to turn the display feature OFF. 2. Press and release the button again to turn the display back ON. Additional options can ...

Hyundai Tucson (LM) 2010-2015 Service Manual: Crash Pad Components and Components Location
Components 1. Main crash pad assembly2. Center fascia upper panel3. Cluster fascia panel4. Cluster fascia lower panel5. Crash pad side cover6. Shrouds upper panel 7. Shrouds lower panel 8. Air vent 9. Crash pad driver's panel (LH)10. Crash pad lower panel11. Reirforce panel12. Center fascia dri ...