Hyundai Tucson: Hydraulic System / Valve Body Repair procedures

Removal
1.
Remove the air duct.
(Refer to Engine Mechanical System - "Air cleaner")
2.
Remove the battery and the battery tray.
(Refer to Engine Electrical System - "Battery")
3.
Remove the under cover (A).

Tightening torque :
19.6 ~ 24.5 N.m (2.0 ~ 2.5 kgf.m, 14.5 ~ 18.1 lb-ft)

4.
Remove the drain plug (A) and reinstall the drain plug after draining ATF totally.

Drain plug tightening torque :
38.2 ~ 48.1 N.m (3.9 ~ 4.9 kgf.m, 28.2 ~ 35.4 lb-ft)

   
Replace the gasket before reinstalling the drain plug.
5.
Disconnect the clamp (A).
6.
Disconnect the air breather hose (B) form the valve body cover.

7.
Remove the valve body cover (B).

Tightening torque :
(A) 13.7 ~ 15.7 N.m (1.4 ~ 1.6 kgf.m, 10.1 ~ 11.6 lb-ft)

   
Replace the gasket (A) before reinstalling the valve body cover.

8.
Remove the bolts (C).
9.
Disconnect the solenoid valve connector (B) and the oil temperature sensor (A) from the valve body.

Tightening torque :
9.8 ~ 11.8 N.m (1.0 ~ 1.2 kgf.m, 7.2 ~ 8.7 lb-ft)

10.
Remove the valve body assembly (A).

Tightening torque :
9.8 ~ 11.8 N.m (1.0 ~ 1.2 kgf.m, 7.2 ~ 8.7 lb-ft)

Installation
1.
Install in the reverse order of removal.
   
Adding Automatic Transaxle Fluid(ATF).
(Refer to Hydraulic System - "Fluid")
Perform Transaxle Control Module(TCM) learning after replacing the valve body to prevent slow transaxle response, jerky acceleration and jerky startup.
(Refer to Automatic Transaxle Control System - "Repair procedures")
Valve Body Components and Components Location
Components Location 1. PCV adjust screw2. Solenoid valve3. Oil temperature sensor4. Accumulator5. Under drive brake (UD/B) pressure flow hole6. Low & reverse brake (LR/B) pressure flow hole ...

Clutch & Brake
...

Other information:

Hyundai Tucson (LM) 2010-2015 Owners Manual: Starting the engine
WARNING Always wear appropriate shoes when operating your vehicle. Unsuitable shoes, such as high heels, ski boots, sandals, flipflops, etc., may interfere with your ability to use the brake, accelerator and clutch pedals. 1.Make sure the parking brake is applied. 2.Make sure the shift lever ...

Hyundai Tucson (LM) 2010-2015 Service Manual: Front Seat Components and Components Location
Components 1. Headrest2. Headrest guide3. Seat back cover4. Seat back heater5. Seat back pad6. Power rumber support assembly7. Seat cushion cover8. Seat cushion heater9. Seat cushion pad10. Shield inner cover11. Front seat buckle12. Seat cushion frame assembly13. Connector bracket LH14. Shield ...

© 2010-2024 www.htmanual.net