Hyundai Tucson: Engine Control System / ETC (Electronic Throttle Control) System Troubleshooting

Hyundai Tucson (LM) 2010-2015 Service Manual / Engine Control / Fuel System / Engine Control System / ETC (Electronic Throttle Control) System Troubleshooting

Fail-Safe Mode

Item	Fail-Safe
ETC Motor	Throttle valve stuck at 7°
TPS	TPS 1 fault	ECM looks at TPS2
	TPS 2 fault	ECM looks at TPS1
	TPS 1,2 fault	Throttle valve stuck at 7°
APS	APS 1 fault	ECM looks at APS 2
	APS 2 fault	ECM looks at APS 1
	APS 1,2 fault	Engine idle state

When throttle value is stuck at 7°, engine speed is limited at below 1,500rpm and vehicle speed at maximum 40 ~ 50 km/h (25 ~ 31 mph)

ETC (Electronic Throttle Control) System Description and Operation

Description The Electronic Throttle Control (ETC) System consists of a throttle body with an integrated control motor and throttle position sensor (TPS). Instead of the traditional throttle cab ...

ETC (Electronic Throttle Control) System Specifications

Specification [Throttle Position Sensor (TPS)] Throttle angle(°)Output Voltage (V)TPS1TPS200.54.5100.964.05201.413.59301.873.14402.322.68502.782.23603.231.77703.691.32804.140.86904.60.41984.650.3 ...

Other information:

Hyundai Tucson (LM) 2010-2015 Service Manual: Temperature Control Actuator Description and Operation
Description 1. Heater unit includes mode control actuator and temperature control actuator. 2. Temperature control actuator is located at the heater unit. It regulates the temperature by the procedure as follows. Signal from control unit adjusts position of temperature door by operating ...

Hyundai Tucson (LM) 2010-2015 Service Manual: Rear Driveshaft Components and Components Location
Components 1. Tone wheel2. BJ joint3. BJ boot4. BJ boot big part band5. BJ boot small part band6. Shaft7. TJ boot small part band8. TJ boot big part band9. TJ boot10. Snap ring11. Circlip12. TJ assembly ...