Hyundai Tucson: General Information / Specifications

Hyundai Tucson (LM) 2010-2015 Service Manual / Driveshaft and axle / General Information / Specifications

Specification
Items
Inner side
Outer side
Front driveshaft
Joint type
TJ
BJ
Max. permissible angle
23.5°
46.5°
Rear driveshaft
Joint type
TJ
BJ
Max. permissible angle
23.5°
46.5°
Rear differential
Oil type
Hypoid gear oil API GL-5, SAE 75W/90
(SHELL SPIRAX X or equivalent)
OIL capacity
0.65 ± 0.05L
Gear type
Hypoid
Diff ratio
2.533
Hypoid gear backlash
0.1 ~ 0.15 mm (0.0028 ~ 0.0059 in.)
Diff gear backlash
0 ~ 0.05 mm (0 ~ 0.0020 in.)

Tightening torque
Items
N.m
kgf.m
lb-ft
Fotrn
Wheel nut
88.3 ~ 107.9
9.0 ~ 11.0
65.1 ~ 79.6
Driveshaft castle nut
294.2 ~ 313.8
30.0 ~32.0
217.0 ~ 231.5
Strut assembly lower mounting bolt
 137.2 ~ 156.9
14.0 ~ 16.0
 101.2 ~ 115.7
Brake caliper mounting bolt
 78.4 ~ 98.0
8.0 ~ 10.0
57.8 ~ 72.3 
Wheel speed sensor mounting bolt
6.9 ~ 10.8
0.7 ~ 1.1
5.1 ~ 8.0
Brake disc mounting screw
4.9 ~ 5.9
0.5 ~ 0.6
3.6 ~ 4.3
Hub assembly mounting bolt
 78.4 ~ 98.0
8.0 ~ 10.0
57.8 ~ 72.3 
Upper roll rod bracket bolt
(A) 107.9 ~ 125.5
11.0 ~ 13.0
79.6 ~ 94.0
(B) 49.0 ~ 63.7
5.0 ~ 6.5
36.2 ~ 47.0
Lower arm ball joint mounting bolt
98.1 ~ 117.7
10.0 ~ 12.0
72.3 ~ 86.8
Tie rod end ball joint mounting nut
23.5~33.3
2.4~3.4
 17.4 ~ 24.6
Rear
Tire wheel hub nut
88.3 ~ 107.9
9.0 ~ 11.0
65.1 ~ 79.6
Driveshaft castle nut
274.6 ~ 294.2
28.0 ~30.0
202.5 ~ 217.0
Shock absorber lower mounting nut
137.2 ~ 156.9 
14.0 ~ 16.0
101.2 ~ 115.7
Brake caliper mounting bolt
49.0 ~ 58.8
5.0 ~ 6.0
36.2 ~ 43.4
Wheel speed sensor mounting bolt
6.9 ~ 10.8
0.7 ~ 1.1
5.1 ~ 8.0
Brake disc mounting screw
4.9 ~ 5.9
0.5 ~ 0.6
3.6 ~ 4.3
Hub assembly mounting bolt
78.5 ~ 88.3
8.0 ~ 9.0
57.9 ~ 65.1
Upper arm mounting bolt
2WD : 137.2 ~ 156.9
14.0 ~ 16.0
101.2 ~ 115.7
4WD : 107.9 ~ 117.7
11.0 ~ 12.0
79.6 ~ 86.8
Lower arm mounting bolt
137.2 ~ 156.9
14.0 ~ 16.0
101.2 ~ 115.7
Assist arm ball joint mounting nut
2WD : 44.1 ~ 53.9
4.5 ~ 5.5
32.5 ~ 39.7
4WD : 137.2 ~ 156.9
14.0 ~ 16.0
 101.2 ~ 115.7
Trailing arm mounting bolt
44.1 ~ 53.9
4.5 ~ 5.5
32.5 ~ 39.7
Propeller shaft
x
Front propeller shaft mounting bolt
49.0 ~ 68.6
5.0 ~ 7.0
36.2 ~ 50.6
Propeller shaft center bearing bracket mounting bolt
49.0 ~ 53.9
5.0 ~ 7.0
36.2 ~ 50.6
Rear Differential
Rear propeller shaft mounting bolt
49.0 ~ 68.6
5.0 ~ 7.0
36.2 ~ 50.6
Rear differential mounting bolt
68.6 ~ 88.3
7.0 ~ 9.0
50.6 ~ 65.1
Differential cover mounting bolt
39.2 ~ 49.0
4.0 ~ 5.0
28.9 ~ 36.2
Rear differential drain plug
49.0 ~ 68.6
5.0 ~ 7.0
36.2 ~ 50.6
Rear differential filler plug
39.2 ~ 58.8
4.0 ~ 6.0
28.9 ~ 43.3

Lubricants
Items
Lubricants
Quantity
Front driveshaft
BJ #25
R 2.0
RBA
130 g
BJ #24
NU 2.0 
RBA
100 g
BJ #24
GAMMA 1.6 GDI
RBA
100 g
BJ #25
UII 1.7
RBA
130 g
VTJ #25
R 2.0
CW-13TJ
150 g
VTJ #24
NU 2.0 
CW-13TJ
120 g
UTJ-II #24
GAMMA 1.6 GDI
CW-13TJ
150 g
VTJ #24
UII 1.7
CW-13TJ
120 g
Rear driveshaft
LBJ #20
RBA
40 g
LTJ #20
CW-13TJ
75 g

General Information
...

Special Service Tools
Special Service Tools Tool(Number and Name)Illustration Use09495-3K000Band installerInstallation of ear type boot band09495-33000PullerRemoval of spider assembly from a drive shaft.09530-2W100Dif ...

Other information:

Hyundai Tucson (LM) 2010-2015 Service Manual: Yaw-rate and G Sensor Repair procedures
Removal 1. Turn ignition switch OFF and disconnect the negative (-) battery cable. 2. Remove the floor console. 3. Disconnect the yaw rate & lateral & Longitudinal G sensor connector (A). 4. Remove the mounting bolts (B). Tightening torque: 7.9 ~ 10.8 N.m (0.8 ~ 1.1 kgf.m ...

Hyundai Tucson (LM) 2010-2015 Service Manual: Starter Specifications
Specification ItemSpecificationRated voltage12 V, 1.2 kWThe number of pinion teeth13Performance[No-load, 11 V]AmpereMax. 70 ASpeedMin. 2,400 rpm ...

© 2010-2025 www.htmanual.net